The results of free thyroxine (FT4) measurements in dried blood spots on filter paper in 744 euthyroid newborns (616 at term, 128 preterm), 10 newborns with congenital hypothyroidism and 4 euthyroid newborns with congenital TBG deficiency are reported. FT4 was measured by column adsorption chromatography of free hormone followed by radioimmunoassay in the eluate. FT4 values averaged 24 +/- 0.2 pmol/L (mean +/- SE) in euthyroid newborns, 23.0 +/- 0.9 pmol/L in euthyroid newborns with TBG deficiency (p = NS), and 5.7 +/- 0.4 pmol/L in hypothyroid newborns (p less than 0.001 vs both groups). Total T4 (TT4) values in newborns with TBG deficiency were not different from those in hypothyroid newborns, but were significantly lower than those in euthyroid newborns without TBG abnormalities. FT4 values were higher in full-term newborns than in preterm newborns (25.2 +/- 0.3 vs 21.2 +/- 0.5 pmol/L, p less than 0.001). In both full-term and preterm newborns FT4 values in dried blood spots increased with birth body weight (bbw), virtually plateauing when bbw was greater than 2,500 g. The cut-off values established on the basis of the bbw (8.0 and 13.1 pmol/L for a bbw of less than or equal to 2,500 g and greater than 2,500 g, respectively) showed higher specificity and predictive value of positive results than the cut-off values based on the gestational age. In any case, the sensitivity, specificity and predictive values of FT4 determinations proved to be higher than those of TT4 and TSH measurements.(ABSTRACT TRUNCATED AT 250 WORDS)