Antifoam-NALCO EC9017A-MSDS PDF
Antifoam-NALCO EC9017A-MSDS PDF
Antifoam-NALCO EC9017A-MSDS PDF
PRODUCT
EC9017A
APPLICATION : ANTIFOAM
2. COMPOSITION/INFORMATION ON INGREDIENTS
Our hazard evaluation has identified the following chemical substance(s) as hazardous. Consult Section 15 for the
nature of the hazard(s).
3. HAZARDS IDENTIFICATION
**EMERGENCY OVERVIEW**
WARNING
Combustible. Irritating to eyes and skin.
Keep away from heat. Keep away from sources of ignition - No smoking. Keep container tightly closed. Do not get
in eyes, on skin, on clothing. Avoid breathing vapor. Use with adequate ventilation. Do not take internally. In case
of contact with eyes, rinse immediately with plenty of water and seek medical advice. After contact with skin, wash
immediately with plenty of soap and water.
Wear suitable protective clothing, gloves and eye/face protection.
Empty product containers may contain product residue. Do not pressurize, cut, heat, weld, or expose containers to
flame or other sources of ignition. Flammable Liquid; may release vapors that form flammable mixtures at or above
the flash point. May evolve oxides of carbon (COx) under fire conditions.
EYE CONTACT :
Can cause moderate irritation.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
1 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
SKIN CONTACT :
Can cause moderate irritation.
INGESTION :
Not a likely route of exposure. May cause nausea and vomiting. Can cause chemical pneumonia if aspirated into
lungs following ingestion. Can cause central nervous system depression.
INHALATION :
Repeated or prolonged exposure may irritate the respiratory tract.
SYMPTOMS OF EXPOSURE :
Acute :
Inhalation of high concentrations of organic solvents can cause nausea, dizziness, vomiting, stupor or
unconsciousness.
Chronic :
Frequent or prolonged contact with product may defat and dry the skin, leading to discomfort and dermatitis.
EYE CONTACT :
Immediately flush eye with water for at least 15 minutes while holding eyelids open. Get medical attention.
SKIN CONTACT :
Immediately wash with plenty of soap and water. If symptoms develop, seek medical advice.
INGESTION :
Do not induce vomiting: contains petroleum distillates and/or aromatic solvents. If conscious, washout mouth and
give water to drink. Get medical attention.
INHALATION :
Remove to fresh air, treat symptomatically. If symptoms develop, seek medical advice.
NOTE TO PHYSICIAN :
Based on the individual reactions of the patient, the physician's judgement should be used to control symptoms and
clinical condition.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
2 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
EXTINGUISHING MEDIA :
Alcohol foam, Carbon dioxide, Foam, Dry powder, Other extinguishing agent suitable for Class B fires, For large
fires, use water spray or fog, thoroughly drenching the burning material.
Water mist may be used to cool closed containers.
PERSONAL PRECAUTIONS :
Restrict access to area as appropriate until clean-up operations are complete. Ensure clean-up is conducted by
trained personnel only. Ventilate spill area if possible. Do not touch spilled material. Remove sources of ignition.
Stop or reduce any leaks if it is safe to do so. Have emergency equipment (for fires, spills, leaks, etc.) readily
available. Use personal protective equipment recommended in Section 8 (Exposure Controls/Personal Protection).
Notify appropriate government, occupational health and safety and environmental authorities.
ENVIRONMENTAL PRECAUTIONS :
Prevent material from entering sewers or waterways.
HANDLING :
Use with adequate ventilation. Keep the containers closed when not in use. Do not use in locations where vapor is
likely to travel to welding flames or arcs or to other hot surfaces. Vapors are much heavier than air, this can result in
uneven distribution. Do not take internally. Do not breathe vapors/gases/dust. Do not get in eyes, on skin, on
clothing. Have emergency equipment (for fires, spills, leaks, etc.) readily available.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
3 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
STORAGE CONDITIONS :
Store away from heat and sources of ignition. Store separately from oxidizers. Store the containers tightly closed.
Use proper grounding procedures. Have appropriate fire extinguishers available in and near the storage area.
ACGIH/TLV :
Substance(s)
Oil Mist TWA: 5 mg/m3
STEL: 10 mg/m3
OSHA/PEL :
Substance(s)
Oil Mist TWA: 5 mg/m3
STEL: 10 mg/m3
Manufacturer's Recommendation :
Substance(s)
Kerosene TWA: 165 ppm , 1,200 mg/m3
ENGINEERING MEASURES :
Use general ventilation with local exhaust ventilation.
RESPIRATORY PROTECTION :
If significant mists, vapors or aerosols are generated an approved respirator is recommended. An organic vapor
cartridge with dust/mist prefilter or supplied air may be used. In event of emergency or planned entry into unknown
concentrations a positive pressure, full-facepiece SCBA should be used. If respiratory protection is required,
institute a complete respiratory protection program including selection, fit testing, training, maintenance and
inspection.
HAND PROTECTION :
Nitrile gloves, Viton# gloves, Polyvinyl alcohol gloves
SKIN PROTECTION :
Wear impervious apron and boots.
EYE PROTECTION :
Wear chemical splash goggles.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
4 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
HYGIENE RECOMMENDATIONS :
Keep an eye wash fountain available. Keep a safety shower available. If clothing is contaminated, remove clothing
and thoroughly wash the affected area. Launder contaminated clothing before reuse.
ODOR Hydrocarbon
Note: These physical properties are typical values for this product and are subject to change.
STABILITY :
Stable under normal conditions.
HAZARDOUS POLYMERIZATION :
Hazardous polymerization will not occur.
CONDITIONS TO AVOID :
Heat and sources of ignition including static discharges.
MATERIALS TO AVOID :
Contact with strong oxidizers (e.g. chlorine, peroxides, chromates, nitric acid, perchlorate, concentrated oxygen,
permanganate) may generate heat, fires, explosions and/or toxic vapors.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
5 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
SENSITIZATION :
This product is not expected to be a sensitizer.
CARCINOGENICITY :
Contains kerosene. Lifetime skin painting tests with fuels and certain fuel fractions derived from crude oil and
cracked stocks, boiling between 175-370 deg C have shown that these middle distillate materials can produce
tumors and/or cancers in laboratory mice. The relationship of these results to humans has not been fully established.
ECOTOXICOLOGICAL EFFECTS :
MOBILITY :
The environmental fate was estimated using a level III fugacity model embedded in the EPI (estimation program
interface) Suite TM , provided by the US EPA. The model assumes a steady state condition between the total input
and output. The level III model does not require equilibrium between the defined media. The information provided is
intended to give the user a general estimate of the environmental fate of this product under the defined conditions of
the models. If released into the environment this material is expected to distribute to the air, water and soil/sediment
in the approximate respective percentages;
BIOACCUMULATION POTENTIAL
Component substances have a potential to bioconcentrate.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
6 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
If this product becomes a waste, it could meet the criteria of a hazardous waste as defined by the Resource
Conservation and Recovery Act (RCRA) 40 CFR 261. Before disposal, it should be determined if the waste meets
the criteria of a hazardous waste.
Hazardous wastes must be transported by a licensed hazardous waste transporter and disposed of or treated in a
properly licensed hazardous waste treatment, storage, disposal or recycling facility. Consult local, state, and federal
regulations for specific requirements.
The information in this section is for reference only and should not take the place of a shipping paper (bill of lading)
specific to an order. Please note that the proper Shipping Name / Hazard Class may vary by packaging, properties,
and mode of transportation. Typical Proper Shipping Names for this product are as follows.
LAND TRANSPORT :
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
7 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
SARA/SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (TITLE III) - SECTIONS 302, 311,
312, AND 313 :
SECTIONS 311 AND 312 - MATERIAL SAFETY DATA SHEET REQUIREMENTS (40 CFR 370) :
Our hazard evaluation has found this product to be hazardous. The product should be reported under the following
indicated EPA hazard categories:
Under SARA 311 and 312, the EPA has established threshold quantities for the reporting of hazardous chemicals.
The current thresholds are: 500 pounds or the threshold planning quantity (TPQ), whichever is lower, for extremely
hazardous substances and 10,000 pounds for all other hazardous chemicals.
FEDERAL WATER POLLUTION CONTROL ACT, CLEAN WATER ACT, 40 CFR 401.15 / formerly Sec. 307, 40
CFR 116.4 / formerly Sec. 311 :
None of the substances are specifically listed in the regulation.
CLEAN AIR ACT, Sec. 111 (40 CFR 60, Volatile Organic Compounds), Sec. 112 (40 CFR 61, Hazardous Air
Pollutants), Sec. 602 (40 CFR 82, Class I and II Ozone Depleting Substances) :
None of the substances are specifically listed in the regulation.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
8 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
CALIFORNIA PROPOSITION 65 :
This product does not contain substances which require warning under California Proposition 65.
Kerosene 8008-20-6
WHMIS CLASSIFICATION :
B3 - Combustible Liquids, D2B - Materials Causing Other Toxic Effects - Toxic Material
AUSTRALIA
All substances in this product comply with the National Industrial Chemicals Notification & Assessment Scheme
(NICNAS).
CHINA
All substances in this product comply with the Chemical Control Law and are listed on the Inventory of Existing
Chemical Substances China (IECSC).
EUROPE
The substances in this preparation have been reviewed for compliance with the EINECS or ELINCS inventories.
JAPAN
All substances in this product comply with the Law Regulating the Manufacture and Importation Of Chemical
Substances and are listed on the Ministry of International Trade & industry List (MITI).
KOREA
All substances in this product comply with the Toxic Chemical Control Law (TCCL) and are listed on the Existing
Chemicals List (ECL)
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
9 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
THE PHILIPPINES
All substances in this product comply with the Republic Act 6969 (RA 6969) and are listed on the Philippine
Inventory of Chemicals & Chemical Substances (PICCS).
Due to our commitment to Product Stewardship, we have evaluated the human and environmental hazards and
exposures of this product. Based on our recommended use of this product, we have characterized the product's
general risk. This information should provide assistance for your own risk management practices. We have
evaluated our product's risk as follows:
Any use inconsistent with our recommendations may affect the risk characterization. Our sales representative will
assist you to determine if your product application is consistent with our recommendations. Together we can
implement an appropriate risk management process.
This product material safety data sheet provides health and safety information. The product is to be used in
applications consistent with our product literature. Individuals handling this product should be informed of the
recommended safety precautions and should have access to this information. For any other uses, exposures should
be evaluated so that appropriate handling practices and training programs can be established to insure safe
workplace operations. Please consult your local sales representative for any further information.
REFERENCES
Threshold Limit Values for Chemical Substances and Physical Agents and Biological Exposure Indices, American
Conference of Governmental Industrial Hygienists, OH., (Ariel Insight# CD-ROM Version), Ariel Research Corp.,
Bethesda, MD.
Hazardous Substances Data Bank, National Library of Medicine, Bethesda, Maryland (TOMES CPS# CD-ROM
Version), Micromedex, Inc., Englewood, CO.
IARC Monographs on the Evaluation of the Carcinogenic Risk of Chemicals to Man, Geneva: World Health
Organization, International Agency for Research on Cancer.
Integrated Risk Information System, U.S. Environmental Protection Agency, Washington, D.C. (TOMES CPS# CD-
ROM Version), Micromedex, Inc., Englewood, CO.
Annual Report on Carcinogens, National Toxicology Program, U.S. Department of Health and Human Services,
Public Health Service.
Title 29 Code of Federal Regulations, Part 1910, Subpart Z, Toxic and Hazardous Substances, Occupational Safety
and Health Administration (OSHA), (Ariel Insight# CD-ROM Version), Ariel Research Corp., Bethesda, MD.
Registry of Toxic Effects of Chemical Substances, National Institute for Occupational Safety and Health, Cincinnati,
OH, (TOMES CPS# CD-ROM Version), Micromedex, Inc., Englewood, CO.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
10 / 11
MATERIAL SAFETY DATA SHEET
PRODUCT
EC9017A
Ariel Insight# (An integrated guide to industrial chemicals covered under major regulatory and advisory programs),
North American Module, Western European Module, Chemical Inventories Module and the Generics Module (Ariel
Insight# CD-ROM Version), Ariel Research Corp., Bethesda, MD.
The Teratogen Information System, University of Washington, Seattle, WA (TOMES CPS# CD-ROM Version),
Micromedex, Inc., Englewood, CO.
Nalco Energy Services, L.P. P.O. Box 87 • Sugar Land, Texas 77487-0087 • (281)263-7000
For additional copies of an MSDS visit www.nalco.com and request access
11 / 11