Freightliner Columbia Workshop Manual
Freightliner Columbia Workshop Manual
Models: CL112
CL120
This is the cut pages sample. Download all 2385 page(s) at: ManualPlace.com
Foreword
The purpose of this manual is to assist the service technician when the vehicle is serviced. Major
drivetrain component service information is not included in this manual, but is located in each
manufacturer’s service manual.
Instructions and procedures are those recommended by Freightliner Trucks or the component
manufacturer.
Maintenance schedules and additional service information are included in the Columbia™
Maintenance Manual.
IMPORTANT: Descriptions and specifications in this manual were in effect at the time
of printing. Freightliner Trucks reserves the right to discontinue models, and to change
specifications or design at any time without notice and without incurring obligation.
Descriptions and specifications contained in this publication provide no warranty,
expressed or implied, and are subject to revision and editions without notice.
Refer to www.Daimler-TrucksNorthAmerica.com and www.FreightlinerTrucks.com for
more information, or contact Daimler Trucks North America LLC at the address below.
Daimler Trucks North America LLC distributes the following major service publications in paper and electronic
(via ServicePro®) formats.
Workshop/Service Workshop/service manuals contain service and repair information for all vehicle
Manual systems and components, except for major components such as engines, trans-
missions, and rear axles. Each workshop/service manual section is divided into
subjects that can include general information, principles of operation, removal,
disassembly, assembly, installation, specifications, and troubleshooting.
Maintenance Manual Maintenance manuals contain routine maintenance procedures and intervals for
vehicle components and systems. They have information such as lubrication
procedures and tables, fluid replacement procedures, fluid capacities, specifica-
tions, and procedures for adjustments and for checking the tightness of fasten-
ers. Maintenance manuals do not contain detailed repair or service information.
Driver’s/Operator’s Driver’s/operator’s manuals contain information needed to enhance the driver’s
Manual understanding of how to operate and care for the vehicle and its components.
Each manual contains a chapter that covers pretrip and post-trip inspections,
and daily, weekly, and monthly maintenance of vehicle components. Driver’s/
operator’s manuals do not contain detailed repair or service information.
Service Bulletins Service bulletins provide the latest service tips, field repairs, product improve-
ments, and related information. Some service bulletins are updates to informa-
tion in the workshop/service manual. These bulletins take precedence over
workshop/service manual information, until the latter is updated; at that time, the
bulletin is usually canceled. The service bulletins manual is available only to
dealers. When doing service work on a vehicle system or part, check for a valid
service bulletin for the latest information on the subject.
IMPORTANT: Before using a particular service bulletin, check the current
service bulletin validity list to be sure the bulletin is valid.
Parts Technical Bulletins Parts technical bulletins provide information on parts. These bulletins contain
lists of parts and BOMs needed to do replacement and upgrade procedures.
Web-based repair, service, and parts documentation can be accessed using the following applications on the
AccessFreightliner.com website.
ServicePro ServicePro® provides Web-based access to the most up-to-date versions of the
publications listed above. In addition, the Service Solutions feature provides di-
agnostic assistance with Symptoms Search, by connecting to a large knowledge
base gathered from technicians and service personnel. Search results for both
documents and service solutions can be narrowed by initially entering vehicle
identification data.
PartsPro PartsPro® is an electronic parts catalog system, showing the specified vehicle’s
build record.
EZWiring EZWiring™ makes Freightliner, Sterling, Western Star, Thomas Built Buses, and
Freightliner Custom Chassis Corporation products’ wiring drawings and floating
pin lists available online for viewing and printing. EZWiring can also be ac-
cessed from within PartsPro.
Warranty-related service information available on the AccessFreightliner.com website includes the following
documentation.
Recall Campaigns Recall campaigns cover situations that involve service work or replacement of
parts in connection with a recall notice. These campaigns pertain to matters of
vehicle safety. All recall campaigns are distributed to dealers; customers receive
notices that apply to their vehicles.
Field Service Campaigns Field service campaigns are concerned with non-safety-related service work or
replacement of parts. All field service campaigns are distributed to dealers; cus-
tomers receive notices that apply to their vehicles.
A B C
00.04
D E F G
11/02/1999 f020045a
A. Section Title
B. Section Number (made up of the Group Number—first two digits, followed by a sequence number—last two digits)
C. Subject Title
D. Manual Title
E. Release (Supplement) Date
F. Subject Number
G. Subject Page Number
The following is a list of definitions for abbreviations and symbols used in Freightliner publications.
A . . . . . . . . . . amperes BBC . . . . . . . bumper-to-back-of-cab CUM . . . . . . . Cummins
AAVA . . . . . . auxiliary air valve assembly BHM . . . . . . . bulkhead module CVSA . . . . . . Commercial Vehicle Safety
ABS . . . . . . . antilock braking system BOC . . . . . . . back-of-cab Alliance
ABS . . . . . . . acrylonitrile-butadiene-styrene BOM . . . . . . . bill of material CWS . . . . . . . collision warning system
A/C . . . . . . . . air conditioner BTDC . . . . . . before top dead center DC . . . . . . . . . direct current
AC . . . . . . . . . alternating current Btu(s) . . . . . British thermal unit(s) DCA . . . . . . . diesel coolant additive
acc . . . . . . . . accessories C . . . . . . . . . . common (terminal) DCDL . . . . . . driver-controlled differential
lock
ACM . . . . . . . aftertreatment control module CAC . . . . . . . charge air cooler
DDA . . . . . . . Detroit Diesel Allison (obs)
ACPU . . . . . air conditioning protection unit CAN . . . . . . . controller area network
DDC . . . . . . . Detroit Diesel Corporation
ADLO . . . . . auto-disengagement lockout CARB . . . . . California Air Resources
Board DDDL . . . . . . Detroit Diesel Diagnostic Link
AGM . . . . . . . absorbed glass mat
CAT . . . . . . . Caterpillar DDE . . . . . . . Detroit Diesel Engines
AGS . . . . . . . automated gear shift
CB . . . . . . . . . circuit breaker DDEC . . . . . Detroit Diesel Electronic
AG2 . . . . . . . Aluminum Generation 2 (engine) Control
a.m. . . . . . . . ante meridiem (midnight to CB . . . . . . . . . citizens’ band
DDR . . . . . . . diagnostic data reader
noon) CBE . . . . . . . cab behind engine
DDU . . . . . . . driver display unit
AM . . . . . . . . amplitude modulation CCA . . . . . . . cold cranking amperes
def . . . . . . . . defrost
amp(s) . . . . ampere(s) CCR . . . . . . . California Code of
Regulations DEF . . . . . . . diesel exhaust fluid
AMT . . . . . . . automated mechanical
transmission CD-ROM . . compact-disc/read-only DFI . . . . . . . . direct fuel injection
AMU . . . . . . . air management unit memory DGPS . . . . . differential global positioning
CDTC . . . . . . constant discharge system
ANSI . . . . . . American National Standards
Institute temperature control DHD . . . . . . . dealer help desk
API . . . . . . . . American Petroleum Institute CEL . . . . . . . check-engine light dia. . . . . . . . . diameter
API . . . . . . . . application programming CFC . . . . . . . chlorofluorocarbons DIAG . . . . . . diagnosis
interface (refrigerant-12) DIP . . . . . . . . dual inline package (switch)
ARI . . . . . . . . Air Conditioning and cfm . . . . . . . . cubic feet per minute DIU . . . . . . . . driver interface unit
Refrigeration Institute CFR . . . . . . . Code of Federal Regulations DLA . . . . . . . datalink adaptor
ASA . . . . . . . American Standards CGI . . . . . . . . clean gas induction DLM . . . . . . . datalink monitor
Association CGW . . . . . . central gateway DLU . . . . . . . data logging unit
ASF . . . . . . . American Steel Foundries CHM . . . . . . . chassis module DMM . . . . . . digital multimeter
ASR . . . . . . . automatic spin regulator CIP . . . . . . . . cold inflation pressure DOC . . . . . . .diesel oxidation catalyst
assy. . . . . . . assembly CLDS . . . . . . cab load disconnect switch DOT . . . . . . .Department of Transportation
ASTM . . . . . American Society for Testing CLS . . . . . . . coolant level sensor
and Materials DPF . . . . . . .diesel particulate filter
cm . . . . . . . . . centimeters DRL . . . . . . .daytime running lights
ATC . . . . . . . automatic temperature control
cm3 . . . . . . . . cubic centimeters DRM . . . . . . .dryer reservoir module
ATC . . . . . . . automatic traction control
CMVSS . . . . Canadian Motor Vehicle DSM . . . . . . .district service manager
ATC . . . . . . . automatic transmission Safety Standard
control DTC . . . . . . .diagnostic trouble code
Co. . . . . . . . . company
ATD . . . . . . . aftertreatment device DTC . . . . . . .discharge temperature control
COE . . . . . . . cab over engine
ATF . . . . . . . . automatic transmission fluid DTNA . . . . . . Daimler Trucks North America
Corp. . . . . . . corporation
ATS . . . . . . . aftertreatment system DVOM . . . . . digital volt/ohm meter
CPC . . . . . . . common powertrain controller
attn . . . . . . . . attention ea. . . . . . . . . .
each
CPU . . . . . . . central processing unit
aux. . . . . . . . auxiliary EBS . . . . . . .electronic braking system
CRT . . . . . . . cathode ray tube
av . . . . . . . . . avoirdupois (British weight ECA . . . . . . .electric clutch actuator
system) cSt . . . . . . . . centistokes (unit of
measurement for describing ECAP . . . . . . electronic control analyzer
AWD . . . . . . . all-wheel drive the viscosity of general programmer
AWG . . . . . . American wire gauge liquids) ECAS . . . . . . electronically controlled air
AWS . . . . . . . American Welding Society cu ft . . . . . . . cubic feet suspension
BAT . . . . . . . battery cu in . . . . . . cubic inches
ECI . . . . . . . . electronically controlled FM . . . . . . . . . frequency modulation HVLP . . . . . . high velocity, low pressure
injection FMCSA . . . . Federal Motor Carrier Safety H/W . . . . . . . hardware
ECL . . . . . . . engine coolant level Administration Hz . . . . . . . . . hertz
ECM . . . . . . . electronic control module FMEA . . . . . failure mode effects analysis IAD . . . . . . . . interaxle differential
ECT . . . . . . . engine coolant temperature FMI . . . . . . . . failure mode indicator ICS . . . . . . . . integrated child seat
ECU . . . . . . . electronic control unit FMSI . . . . . . Friction Materials Standards ICU . . . . . . . . instrumentation control unit
EDM . . . . . . . electronic data monitor Institute
i.d. . . . . . . . . . inside diameter
EEPROM . . electrically erasable FMVSS . . . . Federal Motor Vehicle Safety
Standard ID . . . . . . . . . . identification
programmable read-only
memory FRP . . . . . . . fiberglass reinforced plastic IFI . . . . . . . . . Industrial Fasteners Institute
EFG . . . . . . . electric fuel gauge FSA . . . . . . . field service authorization IFS . . . . . . . . independent front suspension
EFPA . . . . . . electronic foot pedal FSM . . . . . . . fleet service manager IGN . . . . . . . . ignition
assembly ft . . . . . . . . . . feet ILB . . . . . . . . intelligent lightbar
EGR . . . . . . . exhaust gas recirculation ft3 . . . . . . . . . cubic feet ILO . . . . . . . . in lieu of (in the place of)
ELC . . . . . . . extended-life coolant ft3/min . . . . . cubic feet per minute in . . . . . . . . . . inches
EMC . . . . . . . electromagnetic compatibility FTL . . . . . . . . Freightliner in3 . . . . . . . . . cubic inches
EMI . . . . . . . . electromagnetic interference F.U.E.L. . . . . fuel usage efficiency level Inc. . . . . . . . . incorporated
EOA . . . . . . . electric over air g . . . . . . . . . . grams inH2O . . . . . inches of water
EP . . . . . . . . . extreme pressure (describes gal . . . . . . . . . gallons inHg . . . . . . . inches of mercury
an antiwear agent added to I/O . . . . . . . . . input/output
some lubricants) GAWR . . . . . gross axle weight rating
GHG . . . . . . . greenhouse gas IP . . . . . . . . . . instrument panel
EPA . . . . . . . Environmental Protection
Agency GHG14 . . . . greenhouse gas and fuel ISO . . . . . . . . International Organization for
efficiency regulations Standardization
EPS . . . . . . . engine position sensor
GL . . . . . . . . . gear lubricant IVS . . . . . . . . idle validation switch
ESC . . . . . . . electronic stability control
GND . . . . . . . ground k . . . . . . . . . . . kilo (1000)
ESC . . . . . . . enhanced stability control
gpm . . . . . . . gallons per minute kg . . . . . . . . . kilograms
ESD . . . . . . . electrostatic discharge
GPS . . . . . . . global positioning system km . . . . . . . . . kilometers
ESS . . . . . . . engine syncro shift
(transmission) GVWR . . . . . gross vehicle weight rating km/h . . . . . . . kilometers per hour
etc. . . . . . . . . et cetera (and so forth) HBED . . . . . hard-braking event data kPa . . . . . . . . kilopascals
ETEC . . . . . . electronic truck engine control HCM . . . . . . . hybrid control module kW . . . . . . . . kilowatts
EUI . . . . . . . . electronic unit (fuel) injectors HCOE . . . . . high cab over engine L . . . . . . . . . . liters
EVA . . . . . . . electronic vibration analyzer HCU . . . . . . . hydraulic control unit lb . . . . . . . . . . pounds
EXM . . . . . . . (chassis) expansion module HD . . . . . . . . . heavy-duty LBCU . . . . . . lightbar control unit
E85 . . . . . . . . 85% ethanol fuel HDU . . . . . . . hybrid drive unit lbf·ft . . . . . . . pounds force feet
FAS . . . . . . . Freightliner air suspension HEPA . . . . . . high-efficiency particulate air lbf·in . . . . . . pounds force inches
FCCC . . . . . . Freightliner Custom Chassis (filter) LCD . . . . . . . liquid crystal display
Corporation HEST . . . . . . high exhaust system LCOE . . . . . . low cab over engine
FCU . . . . . . . forward control unit temperature LED . . . . . . . light-emitting diode
FET . . . . . . . . field effect transistor HEV . . . . . . . hybrid electric vehicle LFL . . . . . . . . lower flammability limit
Fig. . . . . . . . . figure HFC . . . . . . . hydrogenated fluorocarbons LH . . . . . . . . . left-hand
(refrigerant-134a)
fl oz . . . . . . . fluid ounces LHD . . . . . . . left-hand drive
hp . . . . . . . . . horsepower
FLA . . . . . . . post-1984 advancements LH DR . . . . . left-hand-drive
Freightliner COE hp . . . . . . . . . high pressure
LHK . . . . . . . liters per hundred kilometers
FLB . . . . . . . enhanced Freightliner FLA HRC . . . . . . . Rockwell "C" hardness
LHS . . . . . . . low-hydrogen steel
COE hr(s) . . . . . . . hour(s)
LIN . . . . . . . . Local Interconnect Network
FLC . . . . . . . steel-cab Freightliner 112 HSA . . . . . . . hill start aid
Conventional LLC . . . . . . . limited liability company
HSD . . . . . . . high-side driver
FLD . . . . . . . post-1984 advancements L/min . . . . . . liters per minute
htr. . . . . . . . . heater
Freightliner 112/120 LNG . . . . . . . liquefied natural gas
aluminum-cab Conventional HVAC . . . . . . heating, ventilating, and air
conditioning LPG . . . . . . . liquefied petroleum gas
FLR . . . . . . . forward-looking radar
LPG . . . . . . . liquid propane gas NO . . . . . . . . normally open (terminal or POE . . . . . . . polyol ester
LPI . . . . . . . . liquid propane injection switch) PRD . . . . . . . pressure relief device
LPR . . . . . . . low pressure reservoir NOAT . . . . . . Nitrited Organic Acid PRD . . . . . . . product requirements
Technology document
LRR . . . . . . . low-rolling resistance
NOx . . . . . . . nitrogen oxides PSA . . . . . . . pressure-sensitive adhesive
LSD . . . . . . . low-side driver
no. . . . . . . . . number PSG . . . . . . . pressure sensor governor
LVD . . . . . . . low-voltage disconnect
NPT . . . . . . . national pipe thread psi . . . . . . . . . pounds per square inch
m . . . . . . . . . . meters
NPTF . . . . . . national pipe thread fitting psia . . . . . . . pounds per square inch,
max. . . . . . . . maximum
NT . . . . . . . . . nylon tube or nylon tubing atmosphere
M-B . . . . . . . . Mercedes-Benz
NTSB . . . . . . National Transportation psig . . . . . . . pounds per square inch,
MCM . . . . . . motor control module Safety Board gauge
MESA . . . . . Mining Enforcement Safety OAT . . . . . . . Organic Acid Technology pt . . . . . . . . . . pints
Act
OBD(s) . . . . on-board diagnostic(s) PTCM . . . . . pressure time control module
mfr. . . . . . . . . manufacturer
obs . . . . . . . . obsolete PTO . . . . . . . power takeoff
mi . . . . . . . . . miles
OC . . . . . . . . open circuit PTP . . . . . . . powertrain protection
MID . . . . . . . . message identifier
OCV . . . . . . . open circuit voltage PTPDM . . . . powertrain power distribution
MIL . . . . . . . . malfunction indicator lamp module
(light) o.d. . . . . . . . . outside diameter
O.D. . . . . . . . overdrive pvc . . . . . . . . polyvinyl chloride
MIL . . . . . . . . military specification
OEM . . . . . . . original equipment PWM . . . . . . pulse width modulation
min. . . . . . . . minutes
manufacturer pwr . . . . . . . . power
min. . . . . . . . minimum
OPD . . . . . . . overfill protection device qt . . . . . . . . . . quarts
misc. . . . . . . miscellaneous
OSHA . . . . . Occupational Safety and qty. . . . . . . . . quantity
mL . . . . . . . . milliliters Health Administration R & O . . . . . rust inhibitors and oxidants
mm . . . . . . . . millimeters oz . . . . . . . . . ounces R–12 . . . . . . refrigerant-12 (CFC)
mod. . . . . . . module ozf·in . . . . . . ounces force inches R–134a . . . . refrigerant-134a (HFC)
mpg . . . . . . . miles per gallon p . . . . . . . . . . positive (front axle wheel RAM . . . . . . . random access memory
mph . . . . . . . miles per hour alignment specification)
RC . . . . . . . . . reserve capacity
MSF . . . . . . . modular switch field PACE . . . . . . programmable electronically
controlled engine recirc. . . . . . recirculation
MMT . . . . . . . methylcyclopentadienyl
manganese tricarbonyl PAG . . . . . . . polyalkylene glycol (oil) Ref(s). . . . . . reference(s)
MSHA . . . . . Mining Safety and Health parm . . . . . . parameter regen . . . . . . regeneration
Administration PAS . . . . . . . passenger advisory system RELS . . . . . . reduced engine load at stop
MVDA . . . . . Motor Vehicle Dealers PC . . . . . . . . . personal computer RFI . . . . . . . . radio frequency interference
Association RH . . . . . . . . . right-hand
PCB . . . . . . . printed circuit board
n . . . . . . . . . . negative (front axle wheel RHD . . . . . . . right-hand drive
alignment specification) PDC(s) . . . . parts distribution center(s)
PDI . . . . . . . . pre-delivery inspection RH DR . . . . . right-hand-drive
N . . . . . . . . . . nitrogen
PDM . . . . . . . power distribution module R/I . . . . . . . . . removal and installation
N/A . . . . . . . . not applicable
PEC . . . . . . . power electronics carrier RMA . . . . . . . return material authorization
N·cm . . . . . . Newton-centimeters
PEEC . . . . . . programmable electronic ROM . . . . . . . read-only memory
NC . . . . . . . . . normally closed (terminal or
switch) engine control rpm . . . . . . . . revolutions per minute
NCG . . . . . . . noncondensable gases PID . . . . . . . . parameter identifier R/R . . . . . . . . removal and replacement
NHTSA . . . . National Highway Traffic PKP . . . . . . . Purple-K powder RSA . . . . . . . roll-stability advisor
Safety Administration PLC . . . . . . . power line carrier RSG . . . . . . . road speed governor
NIOSH . . . . . National Institute for PLD . . . . . . . Pumpe-Linie-Düse (pump- RSM . . . . . . . regional service manager
Occupational Safety and line-nozzle) RTS . . . . . . . ready-to-spray
Health PNDB . . . . . power-net distribution box RTV . . . . . . . room temperature vulcanizing
NITE . . . . . . . no idle thermal environment PM . . . . . . . . particulate matter RV . . . . . . . . . recreational vehicle
NLA . . . . . . . no longer available p.m. . . . . . . . post meridiem (noon to SA . . . . . . . . . source address
NLGI . . . . . . National Lubricating Grease midnight)
Institute S-ABA . . . . . self-setting automatic brake
p/n . . . . . . . . part number adjusters
N·m . . . . . . . . Newton-meters PO . . . . . . . . . purchase order
SAE . . . . . . . Society of Automotive TIG . . . . . . . . tungsten inert gas °C . . . . . . . . . degrees Celsius (centigrade)
Engineers TIR . . . . . . . . total indicator reading °F . . . . . . . . . . degrees Fahrenheit
SB . . . . . . . . . service bulletin TMC . . . . . . . Technology and Maintenance # . . . . . . . . . . . number
SBT . . . . . . . seat back thickness Council % . . . . . . . . . . percent
SBW . . . . . . . shift-by-wire TPMS . . . . . . tire pressure monitoring & . . . . . . . . . . and
SCA(s) . . . . Supplemental Coolant system
© . . . . . . . . . . copyright
Additive(s) TPS . . . . . . . thermal protection switch ™ . . . . . . . . . . trademark
SCR . . . . . . . selective catalytic reduction TPS . . . . . . . throttle position sensor
® . . . . . . . . . . registered trademark
SCU . . . . . . . system control unit TRS . . . . . . . timing reference sensor
(speedometer) TSO . . . . . . . truck specification order
SD . . . . . . . . . severe-duty TSU . . . . . . . transmission shift unit
SDU . . . . . . . step deployment unit TXV . . . . . . . thermal expansion valve
SEL . . . . . . . shutdown engine light U.D. . . . . . . . underdrive
SEM . . . . . . . switch expansion module ULSD . . . . . . ultralow-sulfur diesel
SEO . . . . . . . stop engine override UNC . . . . . . . unified national coarse
SHM . . . . . . . switch hub module UNF . . . . . . . unified national fine
SI . . . . . . . . . . service information U.S. . . . . . . . United States
SI . . . . . . . . . . Système International U.S.A. . . . . . United States of America
SID . . . . . . . . subsystem identifier USC . . . . . . . United States customary
SM . . . . . . . . system malfunction (measures)
SMC . . . . . . . sheet molded compound V . . . . . . . . . . volts
S/N . . . . . . . . serial number VCU . . . . . . . vehicle control unit
SOC . . . . . . . state-of-charge VDC . . . . . . . vehicle data computer
SPACE . . . . seat pretensioner activation Vdc . . . . . . . . volts, direct current
for crash survival VIMS . . . . . . vehicle information
enhancement management system
SPG . . . . . . . special purpose grease VIN . . . . . . . . vehicle identification number
SPN . . . . . . . suspect parameter number VIP . . . . . . . . vehicle instrumentation and
sq in . . . . . . square inches protection (Kysor)
SRP . . . . . . . seating reference point VIW . . . . . . . . vehicle interface wiring
SRS . . . . . . . supplemental restraint system (connector)
SRS . . . . . . . synchronous reference VOC . . . . . . . volatile organic compounds
sensor VOM . . . . . . . volt-ohmmeter
SRT . . . . . . . standard repair time VRS . . . . . . . variable resistance sensor
SSD . . . . . . . side sensor display VSG . . . . . . . variable speed governor
SSID . . . . . . . smart switch identification VSS . . . . . . . vehicle speed sensor
SST . . . . . . . stainless steel VSU . . . . . . . vehicle security unit
std. . . . . . . . . standard WB . . . . . . . . wire braid
S/W . . . . . . . . software WI . . . . . . . . . work instructions
SW . . . . . . . . switch WIF . . . . . . . . water-in-fuel
TAM . . . . . . . thermocouple amplifier WOT . . . . . . . wide open throttle
module – ........... minus or negative
TBB . . . . . . . Thomas Built Buses + ........... plus or positive
TBS . . . . . . . turbo boost sensor ± ........... plus-or-minus
TCM . . . . . . . transmission control module > ........... greater than
TCU . . . . . . . transmission control unit < ........... less than
TDC . . . . . . . top dead center x ........... by (used in fastener size
TDR . . . . . . . technician diagnostic routine descriptions)
TEM . . . . . . . truck equipment manufacturer " . . . . . . . . . . . inches
temp . . . . . . temperature ° . . . . . . . . . . . degrees (of an angle)
Vehicle Receipt
Prior to signing for vehicle delivery from a transporter
company, the dealer is responsible for checking for
transporter-related shortages or damages, and noting
these discrepancies on the transporter’s delivery re-
ceipt.
The dealer is also responsible for ensuring that the
vehicle was built according to the Truck Sales Order/
Invoice.
Refer to Section 3 of the Daimler Trucks North
America LLC Warranty Manual for details.
Vehicle Storage
There may be times when a vehicle is stored for long
periods before customer delivery. To protect all ve-
hicles from deterioration and weather, they must be
properly maintained. Adequate protection and stor-
age of new vehicles is the responsibility of the
dealer.
Claims arising from loss and damage to improp-
erly stored vehicles will not be reimbursed.
See Section 3 of the Daimler Trucks North America
LLC Warranty Manual for instructions on storage of
new vehicles.
Pre-Delivery Information
All pre-delivery inspections and services must be
performed at an authorized Daimler Trucks North
America LLC facility, assigned to fully qualified ser-
vice personnel and recorded on the "New Vehicle
Pre-Delivery Inspection" form.
Refer to Section 3 of the Daimler Trucks North
America LLC Warranty Manual for details.
It is recommended the pre-delivery inspection be per-
formed within 30 days of vehicle receipt.
8.8
1 2
8.8
10.9
10/19/93 3 4 f310224a
NOTE: Grade 2 bolts have no grade marking; grade 2 10.9
bolts are rarely used by Freightliner.
These grade markings are used on plain hex-type and 2
10/19/93 f310226a
flanged bolts (capscrews). In addition to the grade
NOTE: In addition to the class markings, the bolt head
markings, the bolt head must also carry the manufactur-
must also carry the manufacturer’s trademark or
er’s trademark or identification.
identification.
1. Grade 2 3. Grade 8
1. Class 8.8 2. Class 10.9
2. Grade 5 4. Grade 8.2
Fig. 4, Bolt Classes
Fig. 2, Bolt Grades
1 2 3
4 5 6
07/27/95 f310466
NOTE: Grade 2 (S.A.E.) and grade A (I.F.I.) nuts have no identification marks or notches; they are rarely used by Freight-
liner. Grade B (I.F.I.) nuts have three identification marks at 120 degrees, or 6 notches. Grade C (I.F.I.) nuts have three
identification marks at 60 degrees, or 12 notches. Grade G (I.F.I.) flanged nuts have six identification marks as shown;
each identification mark may be a dot, line, pair of dots or lines, or any other symbol at the manufacturer’s option.
1. S.A.E. Grade 2 or I.F.I. Grade A Nut (strength compatible with grade 2 bolt.)
2. S.A.E. Grade 5 Nut (strength compatible with grade 5 bolt.)
3. I.F.I. Grade B Nut (strength compatible with grade 5 bolt.)
4. S.A.E. Grade 8 Nut (strength compatible with grade 8 or grade 8.2 bolt.)
5. I.F.I. Grade C Nut (strength compatible with grade 8 or grade 8.2 bolt.)
6. I.F.I. Grade G Nut (flanged locknut; strength compatible with grade 8 or grade 8.2 bolt.)
1
1
2
05/03/91 f310227a
Frame Fasteners
The standard fasteners used to assemble the vehicle
frame and to attach most components to the vehicle
frame are threaded lockbolts (Spin Hucks). These 3
fasteners are covered in Section 31.00. 10/19/93 f310006a
1. Grade 8 Hexhead Bolt
For some other components attached to the frame, 2. Grade 8 Low-Profile Hexhead Bolt
grade 8 and 8.2 phosphate-and oil-coated hexhead 3. Grade C Prevailing Torque Locknut
bolts and grade C cadmium-plated and wax-coated
prevailing torque locknuts are used. The prevailing Fig. 6, Frame Fastener Identification
torque locknuts have distorted sections of threads to
provide torque retention. For attachments where When torquing a fastener, typically 80 to 90 percent
clearance is minimal, low-profile hexhead bolts and of the turning force is used to overcome friction; only
grade C prevailing torque locknuts are used. See 10 to 20 percent is used to stretch the capscrew or
Fig. 6. bolt. About 40 to 50 percent of the turning force is
needed to overcome the friction between the under-
side of the capscrew head or nut and the washer.
Tightening Fasteners Another 30 to 40 percent is needed to overcome the
friction between the threads of the capscrew and the
When a capscrew is tightened to its torque value in a threaded hole, or the friction between the threads of
threaded hole, or a nut is tightened to its torque the nut and bolt.
value on a bolt, the shank of the capscrew or bolt is
stretched slightly. This stretching (tensioning) results The amount of torque required to tighten a fastener
in a preload that reduces fatigue of the fasteners. is reduced when the amount of friction is reduced. If
The torque values given in the tables in Specifica- a fastener is dry (unlubricated) and plain (unplated),
tions, 400 have been calculated to provide enough the amount of friction is high. If a fastener is wax-
clamping force on the parts being fastened, and the coated or oiled, or has a zinc phosphate coating or
correct tensioning of the bolt to maintain the clamp- cadmium plating, the amount of friction is reduced.
ing force. Each of these coatings and combinations of coatings
has a different effect. Using zinc-plated hardened
Use of a torque wrench to tighten fasteners will help flatwashers under the bolt (capscrew) head and nut
prevent overtensioning them. Overtensioning causes reduces the amount of friction. Dirt or other foreign
permanent stretching of the fasteners, which can re-
sult in breakage of the parts or fasteners.
This is the cut pages sample. Download all 2385 page(s) at: ManualPlace.com